众所周知,部门自加载混凝土搅拌车在建筑行业有非常重要的作用,它是使用混凝土施工行业提供了极大的便利,但由于加载混凝土搅拌车的质量好与坏,但对很多朋友来说,是片面的,和理解,事实上,一个合格的中科自上料搅拌车,还需要符合以下标准可以认为是合格的。

As we all know, the Department self loading concrete mixer plays a very important role in the construction industry, which provides great convenience for the use of concrete construction industry. However, due to the quality of loading concrete mixer truck is good or bad, it is one-sided and understanding to many friends. In fact, a qualified Zhongke self loading mixer still needs to meet the following standards, which can be considered as qualified.

车外形尺寸应符合标准。并根据批准的产品图纸和技术文件进行制造。购件和外购件应具有生产厂家的产品合格证，并符合相关标准要求，经搅拌车生产厂家检验合格后方可装配。

The overall dimensions of the vehicle shall meet the national standards. And manufacture according to the approved product drawings and technical documents. The purchased parts and purchased parts shall have the product certificate of the manufacturer and meet the requirements of relevant standards, and can be assembled after passing the inspection of the mixer manufacturer.

装载机的总质量不得超过底盘的许用值，转向轴(轮)的载重质量及横摇稳定性角应符合有关规定。焊缝应平整、笔直。无漏焊、裂纹、渣、表面应无毛刺、覆砂现象。所有裸露的黑色金属表面应进行防锈处理。外观装修漆应美观大方，符合有关规定。

The total mass of the loader shall not exceed the allowable value of the chassis, and the load mass and rolling stability angle of the steering shaft (wheel) shall comply with the relevant provisions. The weld shall be smooth and straight. There shall be no welding leakage, crack, slag, burr and sand covering on the surface. All exposed ferrous metal surfaces shall be rust proof. The exterior decoration paint should be beautiful and in line with relevant regulations.

自上料后，搅拌车的出料速度不小于0.65m3/min，出料残留率小于2-5%。搅拌车进料速度不小于2.7m3/min。从进料到出料，允许的长时间为90mh，搅拌筒的连续输送按规定不超过300转。搅拌车自进料后，速度不得超过50km/h。混合混凝土按规定的搅拌速度和运输时间运交付地点后，其胶结土质量应符合标准要求。

After feeding, the discharging speed of the mixer is not less than 0.65m3/min, and the discharge residual rate is less than 2-5%. The feeding speed of mixer truck shall not be less than 2.7m3/min. The allowable long time from feeding to discharging is 90mh, and the continuous conveying of mixing drum shall not exceed 300 revolutions according to regulations. The speed of mixer truck shall not exceed 50km / h after feeding. After the mixed concrete is transported to the delivery place according to the specified mixing speed and transportation time, the quality of cemented soil shall meet the requirements of national standards.

以上就是小编为大家介绍的关于自上料搅拌车符合标准的要求，希望可以帮助到大家，如有不明白的地方可以关注：http://www.jfhntjbj.com会有在线客服进行详细的解答。

The above is about the self loading mixer meeting the standard requirements. I hope it can help you. If you don't understand, you can pay attention to: http://www.jfhntjbj.com There will be online customer service for detailed answers.