欢迎来到中科聚峰机械有限公司!

24小时服务热线:

400-879-1999

点击拨打服务热线:400-879-1999
当前位置:首页>新闻中心>行业新闻>自动搅拌车15条安全操作规程

自动搅拌车15条安全操作规程

来源:http://www.jfhntjbj.com/ 日期:2022-09-28 发布人:guanli
概述:安全操作是自动搅拌车完成其工作任务的基本保证,也是自动搅拌车操作、维修和周围施工人员人身安全的可靠保证。下面小编为您讲讲自动搅拌车
安全操作是自动搅拌车完成其工作任务的基本保证,也是自动搅拌车操作、维修和周围施工人员人身安全的可靠保证。下面小编为您讲讲自动搅拌车15条安全操作规程。
Safe operation is the basic guarantee for the automatic mixer to complete its work tasks, and is also a reliable guarantee for the operation and maintenance of the automatic mixer and the personal safety of surrounding construction personnel. Here are 15 safety operation rules for automatic mixer truck.
一、自动搅拌车的汽车部分应执行汽车一般安全技术要求的规定。
1、 The vehicle part of the automatic mixer shall comply with the general safety technical requirements for vehicles.
二、自动搅拌车的燃油、液压油、润滑油、制动液、冷却水等应添加充足,质量应符合要求。
2、 The fuel, hydraulic oil, lubricating oil, brake fluid, cooling water, etc. of the automatic mixer shall be added sufficiently, and the quality shall meet the requirements.
三、搅拌筒和滑槽的外观应无裂痕或损伤;滑槽止动器应无松驰和损坏;搅拌筒机架缓冲件应无裂痕或损伤;搅拌叶片磨损应正常。
3、 The appearance of mixing drum and chute shall be free of cracks or damage; The chute stopper shall be free from looseness and damage; The buffer parts of the mixing drum frame shall be free of cracks or damage; The mixing blade shall be worn normally.
四、应检查动力输出装置并确认无螺栓松动及轴承漏油等现象。
4、 Check the power take-off device and make sure there is no loose bolt, bearing oil leakage, etc.
五、启动内燃机应进行预热运转,各仪表指示值正常,制定气压达到规定值,并应低速旋转搅拌筒3~5min,确认一切正常后,方可装料。
5、 When starting the internal combustion engine, the engine shall be preheated. The indicated value of each instrument shall be normal. The specified air pressure shall reach the specified value. The mixing drum shall be rotated at a low speed for 3~5min. After confirming that everything is normal, the material can be loaded.
六、搅拌运输时,混凝土的装载量不得超过额定容量。
6、 During mixing and transportation, the loading capacity of concrete shall not exceed the rated capacity.
七、自动搅拌车装料前,应先将搅拌筒反转,使筒内的积水和杂物排尽。
7、 Before the automatic mixer truck is loaded, the mixing drum shall be reversed to drain the accumulated water and sundries in the drum.
八、装料时,应将操纵杆放在“装料”位置,并调节搅拌筒转速,使进料顺利。
8、 When loading, place the control lever at the "Loading" position and adjust the rotation speed of the mixing drum to ensure smooth feeding.
自动搅拌车
九、运输前,排料槽应锁止在“行驶”位置,不得自由摆动。
9、 Before transportation, the discharge chute shall be locked in the "driving" position and shall not swing freely.
十、运输中,搅拌筒应低速旋转,但不得停转。运送混凝土的时间不得超过规定的时间。
10、 During transportation, the mixing drum shall rotate at a low speed, but shall not stop. The time for transporting concrete shall not exceed the specified time.
十一、搅拌筒由正转变为反转时,应先将操纵手柄放在中间位置,待搅拌筒停转后,再将操纵杆手柄放至反转位置。
11、 When the mixing drum changes from positive to reverse, the operating handle shall be placed in the middle position first, and then the operating lever handle shall be placed in the reverse position after the mixing drum stops rotating.
十二、行驶在不平路面或转弯处应降低车速至15km/h及以下,并暂停搅拌旋转。通过门桥、洞等设施时,不得超过其限制高度及宽度。
12、 The speed shall be reduced to 15km/h or less when driving on uneven roads or at corners, and the mixing rotation shall be suspended. When passing through the gate bridge, hole and other facilities, the height and width shall not exceed the limit.
十三、搅拌装置连续运转时间不宜超过8h。
13、 The continuous operation time of the mixing device should not exceed 8h.
十四、水箱的水位应保持正常。冬季停车时,应将水箱和供水系统的积水放净。
14、 The water level of the water tank shall be kept normal. When parking in winter, the accumulated water in the water tank and water supply system shall be drained.
十五、用于搅拌混凝土时,应在搅拌筒内先加入总需水量2/3的水,然后再加入骨料和水泥按出厂说明书规定的转速和时间进行搅拌。
15、 When mixing concrete, 2/3 of the total water demand shall be added into the mixing cylinder first, and then the aggregate and cement shall be added for mixing according to the speed and time specified in the factory instructions.
自动搅拌车15条安全操作规程相关内容已经讲解完毕了,更多的注意事项就来我们网站http://www.jfhntjbj.com咨询吧!
The relevant contents of the 15 safety operating procedures for automatic mixer have been explained. More precautions can be found on our website http://www.jfhntjbj.com Consult!

截屏,微信识别二维码