欢迎来到莱州中科聚峰机械有限公司!

24小时服务热线:

15053524111

点击拨打服务热线:15053524111
热门关键词: 自动搅拌车,自动上料搅拌车,搅拌一体车
当前位置:首页>新闻中心>行业新闻>搅拌一体车制动器的异常运转应该要如何解决?

搅拌一体车制动器的异常运转应该要如何解决?

来源:http://www.jfhntjbj.com/ 日期:2020-07-18 发布人:guanli 浏览:
概述:自动上料搅拌车是特殊的重型卡车,在搅拌储罐时具有很高的有效载荷,复杂的路况和较大的惯性离心力,这对自动上料搅拌车的制动系统提出了很高的要求。尽管制动系统对于自动上料搅拌车
搅拌一体车是特殊的重型卡车,在搅拌储罐时具有很高的有效载荷,复杂的路况和较大的惯性离心力,这对自动上料搅拌车的制动系统提出了很高的要求。尽管制动系统对于自动上料搅拌车系统非常重要,但确定自动上料搅拌车安全性的首要考虑因素是车辆的制动距离和制动器的热降解。
The automatic loading mixer is a special heavy truck, which has high payload, complex road conditions and large inertial centrifugal force when mixing the tank, which puts forward high requirements for the braking system of the automatic charging mixer. Although the braking system is very important for the automatic charging mixer system, the first consideration for determining the safety of the automatic charging mixer is the braking distance of the vehicle and the thermal degradation of the brake.
1.制动时发出异常声音
1. Abnormal sound when braking
踩刹车时,刹车系统会产生剧烈的金属摩擦。这可能是由于刹车片中的异物,刹车盘上的锈蚀等引起的。
When stepping on the brake, the brake system will produce severe metal friction. This may be due to foreign matter in the brake pads, corrosion on the brake discs, etc.
2,刹车踏板行程变长
2. The brake pedal travel becomes longer
刹车变软时,您会看到一个笔直的白点。较长的制动行程的原因主要是由于空气进入制动系统,缺少制动油,可能的泄漏以及制动衬块的严重磨损。
When the brakes are soft, you will see a straight white dot. The long brake stroke is mainly due to air entering the brake system, lack of brake oil, possible leakage and severe wear of brake pads.
3,刹车偏
3. Brake deviation
制动偏差现象不太常见,主要反映了在施加制动时方向盘偏向一侧的事实。造成这种现象的原因可能是制动衬块的偏心磨损和制动缸的问题。
The phenomenon of brake deviation is not very common, which mainly reflects the fact that the steering wheel deviates to one side when braking is applied. The cause of this phenomenon may be the eccentric wear of brake pads and the problem of brake cylinder.
4,刹车变得越来越困难
4. Braking becomes more and more difficult
许多自动上料搅拌车都伴随着增强制动的问题。加强制动器的主要原因是真空助力器失效。刹车不辅助,经常使用刹车。
Many automatic charging mixers are accompanied by the problem of enhanced braking. The main reason to strengthen the brake is the failure of vacuum booster. The brake doesn't assist. The brake is often used.
5,刹车回弹
5. Brake rebound
许多自动上料搅拌车伙伴都遇到过这种情况,但是当使用制动器时,会出现一种现象,其中上肢会弹回到制动踏板上,这主要是由于制动盘表面的不平整,垫子和钢环变形。
Many partners of automatic charging mixer have encountered this situation, but when using the brake, there will be a phenomenon, in which the upper limb will bounce back to the brake pedal, which is mainly due to the uneven surface of the brake disc and deformation of the cushion and steel ring.

截屏,微信识别二维码

微信号:

点击微信号复制,添加好友

 打开微信